Product ID:QUIKRETE ASPHALT REPAIR, QK-952
MSDS Date:11/05/1992
FSC:5610
NIIN:00N061241
MSDS Number: BXYLB

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 612-835-3434

Preparer: MARK HORTON

Cage: CHEMR

Telephone: 612-835-3434;800-424-9300(CHEMTREC)

Cage: 63472

NO INGREDIENT FOR THIS FORMULATION_INGREDIENT

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MOD IRRIT. MAY CAUSE REVERSIBLE
CORNEAL INJURY. SKIN: MOD IRRIT. MAY CAUSE DERM & ALLERGIC
RESPONSES. RPTD/PRLNGD OVEREXP MAY CAUSE SENSITIZATION. INHAL: RESP
IRRIT, INTOX & CNS DEPRESS. OVEREXP SHOWN BY HDCH, DIZZ &
CONFUSION TO COMA. MATL ASPIR INTO LUNGS MAY CAUSE CHEMICAL PNEUM.
INGEST: MAY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CAUSE NAUSEA & VOMIT. NO SPECIFIC
EFFECTS KNOWN. CHRONIC: STUDIES SUGGEST THAT SOLVENT CHRONIC
OVEREXP &/SYSTEMIC TOXICITY EFTS ARE TARGETED AT THE KIDNEYS & CNS.
DELIBERATE & RPTD INHAL OF CONC SOLV VAPORS MAY CAUSE PERMANENT
NEURAL DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING PULMONARY &
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZ
COMPONENTS.

First Aid:EYES:FLUSH W/PLENTY OF H*2O AT LEAST 15 MINS. OBTAIN IMMED MD
ATTN. SKIN:REMOVE CONTAMD CLTHG. WASH AFFECTED AREA(S) THORO W/SOAP
& WATER. CONSULT MD. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT,
GIV E O*2. ADMIN ARTF RESP IF NOT BRTHG. OBTAIN MD ATTN. INGEST:DO
NOT INDUCE VOMIT. GIVE H*2O/MILK IF VICTIM IS CONSCIOUS & NOT DROW.
SHOULD VOMIT OCCUR, BE SURE TO KEEP VICTIM'S HEAD BELOW HIPS
(SUPDAT)

Flash Point Method:TCC
Flash Point:108F,42C
Lower Limits:0.9%
Upper Limits:4.9%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
USE WATER TO COOL EXPOSED CNTNRS. WATER STREAM DIRECTED INTO FIRE
MAY CAUSE FROTHING W/SUBSEQUENT (SUPDAT)
Unusual Fire/Explosion Hazard:IRRIT &/TOX GASES/FUMES MAY BE GENERATED
BY THERM DECOMP/COMBUST. CLSD CNTNRS MAY RUPTURE/EXPLODE(DUE TO
PRESS BUILD-UP) WHEN EPXOSED TO EXTREME HEAT.(SUPDAT)

Spill Release Procedures:VENT AREA. WEAR APPROP PROT EQUIP DURING
CLEANUP. ELIM SOURCE OF IGNIT. CONTAIN SPILL. ABSORB W/INERT
MATL(VERMICULITE). PLACE IN CNTNRS W/LIDS. COVER LOOSELY & REMOVE
TO APPROP WASTE AREA. WASH SPILL AREA. PVNT WASHINGS FROM ENTERING
WATERWAY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT TAKE INTERNALLY. AVOID CONT
W/EYES, SKIN & CLTHG. AVOID BRTHG VAP/DUST/MIST. TIGHTLY RESEAL ALL
PARTIALLY USED CNTNRS. USE ONLY W/ADEQ VENT.
Other Precautions:STORE AWAY FROM SOURCES OF IGNIT. KEEP OUT OF REACH
OF CHILDREN. DO NOT RESUE EMTPY CNTNR W/OUT COMMERCIAL
CLEAN/RECONDITION. STORE EMPTY CNTNR AWAY FROM HEAT & FLAME.

Respiratory Protection:IF TLV EXCEEDED, IF USE IN POORLY VENT CONFINED
SPACE/AREA W/LIM VENT, USE NIOSH/MSHA APPRVD ORG VAP CARTRIDGE RESP
I/A/W/APPLIC HLTH & SAFETY REGS. IF VAP LEVELS ARE 10 X TLV/>, USE
NIOSH/MSHA APPRVD SUPPLIED-AIR RESP I/A/W APPLIC(ING 4)
Ventilation:LOCAL EXHAUST AS NEEDED TO CONTROL VAPOR/DUST LEVELS TO
BELOW RECOMMENDED LIMITS.
Protective Gloves:NITRILE, PVA, PVC, VITON GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS.
Other Protective Equipment:ACCESSIBLE EYE WASH & SAFETY SHOWER. CLEAN
PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:SPREAD OF FIRE. EXPLO HAZ:VAP IS HVR/AIR & MAY TRAVEL
ALONG GROUND TO BE REIGNIT AT LOCATIONS DISTANT FROM THIS SOURCE;
FLASH BACK OF FLAME MAY OCCUR. EMPTY CNTNRS MAY CONTAIN EXPLO VA
PS/DANGEROUS RESIDUES. DO NOT CUT, PUNCTURE/WELD ON/NEAR CNTNR. 1ST
AID PROC:TO AVOID ASPIR OF VOMIT INTO LUNGS.(ING 3)

Boiling Pt:B.P. Text:300F,149C
Vapor Pres:27 @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.05
Evaporation Rate & Reference:SLOWER (N-BUAC)
Solubility in Water:NEG(<0.1)
Appearance and Odor:BLACK VISCOUS SEMI-PASTE WITH MINERAL SPIRITS ODOR.
Percent Volatiles by Volume:47

Stability Indicator/Materials to Avoid:YES
STRONG BASES OR OXIDANTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:ACRID FUMES. OXIDES OF CARBON.

Waste Disposal Methods:REVIEW ALL LOCAL, STATE & FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION FOR APPROPRIATE DISPOSAL PROCEDURES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.